PlainWorker
Employers › AL

Manufacturing · Elba, AL

Inzi Controls Alabama, INC.

According to OSHA enforcement records (2010–2026), Inzi Controls Alabama, INC. ranks #1,257 of 99,447 penalized U.S. employers by total current penalty, with a concerning safety record: 34 violations across 8 inspections.

Top 1% by penalty68% serious
$121,999
OSHA penalties
34
Violations cited
8
OSHA inspections
#1,257
of 99,447 penalized employers

Inzi Controls Alabama, INC. in Elba, AL has been the subject of 8 OSHA workplace inspections and 34 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $121,999. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected Inzi Controls Alabama, INC. 8 times over 10 years, roughly once every couple of years. These inspections resulted in 34 violations, averaging 4.3 per inspection, above what's typical for a single visit. According to OSHA enforcement records, its total current penalty ranks #1,257 of 99,447 penalized U.S. employers (the top 1% of penalized employers nationally). Of these, 23 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this runs well above peers (3.1x the sector average) on inspection frequency. For comparison, Johnson Controls Battery Group, INC. in Holland, OH is another manufacturing employer with 4 OSHA inspections on record and $122,000 in current penalties.

4.3
violations per inspection
67.6%
of violations were serious
#1,257
of 99,447 penalized employers

Compliance score

F 28/100
  • F OSHA safety compliance: 34 violations across 8 OSHA inspections (4.3 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.

Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.

Open my watchlist

How Inzi Controls Alabama, INC. compares on OSHA penalties

Total current penalty vs the Manufacturing per-employer average

in penalties

What this shows Inzi Controls Alabama, INC. runs far above peers (7.7x the sector average) in total OSHA penalties.

Source U.S. Department of Labor, OSHA enforcement extracts As of 2026

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$121,999 Bottom 1% least affordable more affordable than 1% of 99,447 U.S. employers with a penalty

$0–$5,000: 43,959 U.S. employers with a penalty (44%). Below this entry. $5,000–$10,000: 20,304 U.S. employers with a penalty (20%). Below this entry. $10,000–$15,000: 11,027 U.S. employers with a penalty (11%). Below this entry. $15,000–$20,000: 6,546 U.S. employers with a penalty (7%). Below this entry. $20,000–$25,000: 4,175 U.S. employers with a penalty (4%). Below this entry. $25,000–$30,000: 2,877 U.S. employers with a penalty (3%). Below this entry. $30,000–$35,000: 2,036 U.S. employers with a penalty (2%). Below this entry. $35,000–$40,000: 1,493 U.S. employers with a penalty (2%). Below this entry. $40,000–$45,000: 1,095 U.S. employers with a penalty (1%). Below this entry. $45,000–$50,000: 785 U.S. employers with a penalty (1%). Below this entry. $50,000+: 5,150 U.S. employers with a penalty (5%). This entry ($121,999) is well above this band, the chart's rightmost open-ended bucket. This employer: $121,999 $0 $55,000+ every penalized U.S. employer, bucketed by value

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is Inzi Controls Alabama, INC..

Frequently inspected, many findingsRarely inspected, many findingsFrequently inspected, clean recordBelow median on both8.08.088.08.10.215.631.046.461.8OSHA inspectionsViolations citedAJM PACKAGING CORPOR…, OSHA inspections: 8 · Violations cited: 13CRYSTAL FINISHING SY…, OSHA inspections: 8 · Violations cited: 32BO'S PALLETS, INC., OSHA inspections: 8 · Violations cited: 21PREMIER TOOL & DIE C…, OSHA inspections: 8 · Violations cited: 46UNIVERSAL STAMPING INC, OSHA inspections: 8 · Violations cited: 59ABSTRETCH LLC, OSHA inspections: 8 · Violations cited: 27BEST DIAMOND PLASTIC…, OSHA inspections: 8 · Violations cited: 8MADISON-KIPP CORPORA…, OSHA inspections: 8 · Violations cited: 4ARCONIC US LLC, OSHA inspections: 8 · Violations cited: 8MARTINREA INDUSTRIES…, OSHA inspections: 8 · Violations cited: 44VEHTEK SYSTEMS INC., OSHA inspections: 8 · Violations cited: 18IAC SPRINGFIELD LLC, OSHA inspections: 8 · Violations cited: 32MOBIS ALABAMA LLC, OSHA inspections: 8 · Violations cited: 3AMWARE PALLET SERVIC…, OSHA inspections: 8 · Violations cited: 17BRIDGFORD FOOD PROCE…, OSHA inspections: 8 · Violations cited: 28NORTH AMERICAN LIGHT…, OSHA inspections: 8 · Violations cited: 16HORMEL FOODS CORPORA…, OSHA inspections: 8 · Violations cited: 14IOWA PREMIUM, LLC, OSHA inspections: 8 · Violations cited: 22REA MAGNET WIRE COMP…, OSHA inspections: 8 · Violations cited: 13MICELI DAIRY PRODUCT…, OSHA inspections: 8 · Violations cited: 38Inzi Controls Alabam…, OSHA inspections: 8 · Violations cited: 34
Inzi Controls Alabama, INC. has 8 OSHA inspections on record and 34 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

Inzi Controls Alabama, INC. in the Manufacturing enforcement ledger

Among 35,243 Manufacturing employers with OSHA penalties on file, Inzi Controls Alabama, INC. ranks #690 at $121,999 current penalty.

How Inzi Controls Alabama, INC. Compares

Inzi Controls Alabama, INC.'s 4.25 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs far above peers (7.7x the sector average).

Enforcement detail

OSHA Inspection History

Total Inspections

8

First Inspection

2013-09-04

Last Inspection

2023-08-31

Inspection Span

10 yrs

Violations / Inspection

4.3

Avg Penalty / Inspection

$15,250

Industry Avg / Inspection

$6,093

What this shows 8 inspections over 10 years, averaging 4.3 violations per visit. That's $15,250 per inspection vs. the Manufacturing average of $6,093.

Enforcement detail

Violation Breakdown

23

Serious

67.6% of total

0

Willful

0.0% of total

4

Repeat

11.8% of total

7

Other-Than-Serious

20.6% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Enforcement detail

Penalty Analysis

Initial Penalty Assessed

$198,111

Current Penalty Amount

$121,999

Penalty Reduction

38.4%

What this shows Penalties were reduced by $76,112 from the initial assessment of $198,111. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Industry Safety Context: Manufacturing

How Inzi Controls Alabama, INC. compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric Inzi Controls Alabama, INC. Industry Avg
Inspections 8 2.6
Violations 34 8.0
Total Penalty $121,999 $15,763
Avg Penalty per Inspection $15,250 $6,093
View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for Inzi Controls Alabama, INC., both outside AL so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($121,999 here).

Johnson Controls Battery Group, INC. $122,000 OH Blue Bird Corporation $121,963 GA Fred Geisel $121,946 GA Magnesita Refractories $122,065 PA

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (8 inspections here).

Ajm Packaging Corporation 8 insp. Vineland, NJ Crystal Finishing Systems, INC. 8 insp. Mosinee, WI Bo's Pallets, INC. 8 insp. Adairsville, GA Premier Tool & Die Cast CORP 8 insp. Berrien Springs, MI

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

Johnson Controls Battery Group, INC.
Holland, OH
4 inspections $122,000
Tri-State Envelope Corporation
Ashland, PA
2 inspections $9,260
Blue Bird Corporation
Fort Valley, GA
10 inspections $121,963
Fred Geisel
Marble Hill, GA
5 inspections $121,946
Magnesita Refractories
York, PA
2 inspections $122,065

Compare Inzi Controls Alabama, INC. vs Johnson Controls Battery Group, INC. side-by-side →

What to do with this record

Use Inzi Controls Alabama, INC.'s enforcement history as one data point, not the whole picture.

  • A single employer's record can look unusual in isolation. Compare Inzi Controls Alabama, INC. against Johnson Controls Battery Group, INC., a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
  • See whether Inzi Controls Alabama, INC.'s inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
  • Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is Inzi Controls Alabama, INC. safe to work at? ▼
Based on OSHA records, Inzi Controls Alabama, INC.'s workplace safety record is concerning, with multiple serious compliance issues. The employer has 34 violations across 8 inspections, including 23 serious violations. Compared to Manufacturing industry peers, this is above average for penalties. Review the full inspection history below for details.
How many OSHA violations does Inzi Controls Alabama, INC. have? ▼
Inzi Controls Alabama, INC. has 34 OSHA violations on record, including 23 serious, 0 willful, and 4 repeat violations. The total current penalty amount is $121,999.
How many OSHA inspections has Inzi Controls Alabama, INC. had? ▼
Inzi Controls Alabama, INC. has had 8 OSHA inspections, with the first recorded on 2013-09-04 and the most recent on 2023-08-31. This averages 4.3 violations per inspection.
What is the total penalty amount for Inzi Controls Alabama, INC.? ▼
Inzi Controls Alabama, INC. has been assessed $121,999 in current OSHA penalties, reduced from an initial assessment of $198,111 (a 38.4% reduction).
Does Inzi Controls Alabama, INC. have any serious or willful violations? ▼
Yes. Inzi Controls Alabama, INC. has 23 serious violations, and 4 repeat violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.
What industry does Inzi Controls Alabama, INC. operate in? ▼
Inzi Controls Alabama, INC. operates in the Manufacturing sector (NAICS code 336390). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.
Where does Inzi Controls Alabama, INC. rank nationally on OSHA penalties? ▼
Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, Inzi Controls Alabama, INC. ranks #1,257 (the top 1% of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.
How does Inzi Controls Alabama, INC.'s safety record compare to industry average? ▼
Inzi Controls Alabama, INC.'s total OSHA penalty of $121,999 is above the Manufacturing industry average of $15,763 per employer (7.7x the average). The employer has 8 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Johnson Controls Battery Group, INC. in Holland, OH is a similar manufacturing employer with $122,000 in current penalties.
Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.

Verify with OSHA establishment search →

Every figure on PlainWorker is rendered directly from official U.S. Department of Labor OSHA and Wage & Hour Division enforcement records, no number is typed in by an editor. This employer's ratios (penalty-per-violation, industry comparisons) are computed live from the 8 inspections on record. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of 2026.