Manufacturing · Dubois, PA

Sensus USA INC.

According to OSHA enforcement records (2010–2026), Sensus USA INC. ranks #46,053 of 99,447 penalized U.S. employers by total current penalty, with a mixed safety record: 6 violations across 7 inspections.

Upper half by penalty67% serious

Compiled by Plainworker · September 6, 2026

$6,935
OSHA penalties: 6
Violations cited: 7
OSHA inspections: #46,053
of 99,447 penalized employers

Sensus USA INC. in Dubois, PA has been the subject of 7 OSHA workplace inspections and 6 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $6,935. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected Sensus USA INC. 7 times over 10 years, roughly once every couple of years. These inspections resulted in 6 violations, averaging 0.9 per inspection, on the lighter side. According to OSHA enforcement records, its total current penalty ranks #46,053 of 99,447 penalized U.S. employers (the upper half of penalized employers nationally). Of these, 4 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this runs well above peers (2.7x the sector average) on inspection frequency. For comparison, Connelly Paving CO. in Oklahoma City, OK is another manufacturing employer with 4 OSHA inspections on record and $6,931 in current penalties.

0.9
violations per inspection: 66.7%
of violations were serious: #46,053
of 99,447 penalized employers

Compliance score

C 78/100

C OSHA safety compliance: 6 violations across 7 OSHA inspections (0.9 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.

Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.

Open my watchlist

Sensus USA INC.

$6,935
Manufacturing avg

$15,763

What this shows Sensus USA INC. runs moderately below peers (0.4x the sector average) in total OSHA penalties.

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$6,935 Bottom 46% least affordable more affordable than 46% of 99,447 U.S. employers with a penalty

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is Sensus USA INC..

Sensus USA INC. has 7 OSHA inspections on record and 6 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

Sensus USA INC. in the Manufacturing enforcement ledger

In Manufacturing, Sensus USA INC. sits at penalty rank #19,928 of 35,243 penalized establishments ($6,935 assessed).

How Sensus USA INC. Compares

Sensus USA INC.'s 0.86 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs moderately below peers (0.4x the sector average).

Total Inspections

First Inspection

2013-06-24

Last Inspection

2023-08-25

Inspection Span

10 yrs

Violations / Inspection

0.9

Avg Penalty / Inspection

$991

Industry Avg / Inspection

$6,093

What this shows 7 inspections over 10 years, averaging 0.9 violations per visit. That's $991 per inspection vs. the Manufacturing average of $6,093.

Serious

66.7% of total

Willful

0.0% of total

Repeat

0.0% of total

Other-Than-Serious

33.3% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Initial Penalty Assessed

$10,531

Current Penalty Amount

$6,935

Penalty Reduction

34.1%

What this shows Penalties were reduced by $3,596 from the initial assessment of $10,531. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Industry Safety Context: Manufacturing

How Sensus USA INC. compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric	Sensus USA INC.	Industry Avg
Inspections	7	2.6
Violations	6	8.0
Total Penalty	$6,935	$15,763
Avg Penalty per Inspection	$991	$6,093

View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for Sensus USA INC., both outside PA so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($6,935 here).

Ribus, INC. $6,936 NV Connelly Paving CO. $6,931 OK O Thronas INC $6,930 HI PDQ Printing, INC. $6,930 NV

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (7 inspections here).

SFC Global Supply Chain, INC. 7 insp. Salina, KS LB Steel, LLC 7 insp. Harvey, IL Arconics Davenport Works 7 insp. Bettendorf, IA The Western Sugar Cooperative 7 insp. Fort Morgan, CO

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

Compare Sensus USA INC. vs Ribus, INC. side-by-side →

What to do with this record

Use Sensus USA INC.'s enforcement history as one data point, not the whole picture.

A single employer's record can look unusual in isolation. Compare Sensus USA INC. against Ribus, INC., a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
See whether Sensus USA INC.'s inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is Sensus USA INC. safe to work at? ▼

Based on OSHA records, Sensus USA INC.'s workplace safety record is mixed, with some compliance concerns. The employer has 6 violations across 7 inspections, including 4 serious violations. Compared to Manufacturing industry peers, this is below average for penalties. Review the full inspection history below for details.

How many OSHA violations does Sensus USA INC. have? ▼

Sensus USA INC. has 6 OSHA violations on record, including 4 serious, 0 willful, and 0 repeat violations. The total current penalty amount is $6,935.

How many OSHA inspections has Sensus USA INC. had? ▼

Sensus USA INC. has had 7 OSHA inspections, with the first recorded on 2013-06-24 and the most recent on 2023-08-25. This averages 0.9 violations per inspection.

What is the total penalty amount for Sensus USA INC.? ▼

Sensus USA INC. has been assessed $6,935 in current OSHA penalties, reduced from an initial assessment of $10,531 (a 34.1% reduction).

Does Sensus USA INC. have any serious or willful violations? ▼

Yes. Sensus USA INC. has 4 serious violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.

What industry does Sensus USA INC. operate in? ▼

Sensus USA INC. operates in the Manufacturing sector (NAICS code 332439). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.

Where does Sensus USA INC. rank nationally on OSHA penalties? ▼

Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, Sensus USA INC. ranks #46,053 (the upper half of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.

How does Sensus USA INC.'s safety record compare to industry average? ▼

Sensus USA INC.'s total OSHA penalty of $6,935 is below the Manufacturing industry average of $15,763 per employer. The employer has 7 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Connelly Paving CO. in Oklahoma City, OK is a similar manufacturing employer with $6,931 in current penalties.

Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.