Manufacturing · New Berlin, WI

Acs Group, INC.

According to OSHA enforcement records (2010–2026), Acs Group, INC. ranks #2,747 of 99,447 penalized U.S. employers by total current penalty, with a concerning safety record: 33 violations across 12 inspections.

Top 5% by penalty76% serious

Compiled by Plainworker · September 6, 2026

$75,669
OSHA penalties: 33
Violations cited: 12
OSHA inspections: #2,747
of 99,447 penalized employers

Acs Group, INC. in New Berlin, WI has been the subject of 12 OSHA workplace inspections and 33 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $75,669. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected Acs Group, INC. 12 times over 14 years, roughly once every couple of years. These inspections resulted in 33 violations, averaging 2.8 per inspection, above what's typical for a single visit. According to OSHA enforcement records, its total current penalty ranks #2,747 of 99,447 penalized U.S. employers (the top 5% of penalized employers nationally). Of these, 25 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this runs well above peers (4.6x the sector average) on inspection frequency. For comparison, Mobis North America in Detroit, MI is another manufacturing employer with 9 OSHA inspections on record and $75,700 in current penalties.

2.8
violations per inspection: 75.8%
of violations were serious: #2,747
of 99,447 penalized employers

Compliance score

D 50/100

D OSHA safety compliance: 33 violations across 12 OSHA inspections (2.8 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.

Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.

Open my watchlist

Acs Group, INC.

$75,669
Manufacturing avg

$15,763

What this shows Acs Group, INC. runs well above peers (4.8x the sector average) in total OSHA penalties.

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$75,669 Bottom 3% least affordable more affordable than 3% of 99,447 U.S. employers with a penalty

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is Acs Group, INC..

Acs Group, INC. has 12 OSHA inspections on record and 33 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

Acs Group, INC. in the Manufacturing enforcement ledger

Manufacturing sector: Acs Group, INC. is the #1,430 heaviest OSHA penalty carrier of 35,243 employers with nonzero fines ($75,669).

How Acs Group, INC. Compares

Acs Group, INC.'s 2.75 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs well above peers (4.8x the sector average).

Total Inspections

First Inspection

2010-07-01

Last Inspection

2024-08-08

Inspection Span

14 yrs

Violations / Inspection

2.8

Avg Penalty / Inspection

$6,306

Industry Avg / Inspection

$6,093

What this shows 12 inspections over 14 years, averaging 2.8 violations per visit. That's $6,306 per inspection vs. the Manufacturing average of $6,093.

Serious

75.8% of total

Willful

0.0% of total

Repeat

6.1% of total

Other-Than-Serious

18.2% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Initial Penalty Assessed

$118,285

Current Penalty Amount

$75,669

Penalty Reduction

36.0%

What this shows Penalties were reduced by $42,616 from the initial assessment of $118,285. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Industry Safety Context: Manufacturing

How Acs Group, INC. compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric	Acs Group, INC.	Industry Avg
Inspections	12	2.6
Violations	33	8.0
Total Penalty	$75,669	$15,763
Avg Penalty per Inspection	$6,306	$6,093

View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for Acs Group, INC., both outside WI so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($75,669 here).

Mobis North America $75,700 MI Woodward Iodine Corporation $75,600 OK Agco Corporation $75,747 KS Intex Millwork Solutions, LLC $75,770 NJ

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (12 inspections here).

Nasoya Foods USA, LLC 12 insp. Ayer, MA The Doe Run Company 12 insp. Herculaneum, MO Motor City Stamping INC 12 insp. Chesterfield, MI Erie Strayer Company 12 insp. Erie, PA

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

Fashion Graphics, LLC

5 inspections $75,647

Mobis North America

Detroit, MI

9 inspections $75,700

Tulip Corporation

Milwaukee, WI

11 inspections $75,613

Woodward Iodine Corporation

Woodward, OK

2 inspections $75,600

Compare Acs Group, INC. vs Fashion Graphics, LLC side-by-side →

What to do with this record

Use Acs Group, INC.'s enforcement history as one data point, not the whole picture.

A single employer's record can look unusual in isolation. Compare Acs Group, INC. against Fashion Graphics, LLC, a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
See whether Acs Group, INC.'s inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is Acs Group, INC. safe to work at? ▼

Based on OSHA records, Acs Group, INC.'s workplace safety record is concerning, with multiple serious compliance issues. The employer has 33 violations across 12 inspections, including 25 serious violations. Compared to Manufacturing industry peers, this is above average for penalties. Review the full inspection history below for details.

How many OSHA violations does Acs Group, INC. have? ▼

Acs Group, INC. has 33 OSHA violations on record, including 25 serious, 0 willful, and 2 repeat violations. The total current penalty amount is $75,669.

How many OSHA inspections has Acs Group, INC. had? ▼

Acs Group, INC. has had 12 OSHA inspections, with the first recorded on 2010-07-01 and the most recent on 2024-08-08. This averages 2.8 violations per inspection.

What is the total penalty amount for Acs Group, INC.? ▼

Acs Group, INC. has been assessed $75,669 in current OSHA penalties, reduced from an initial assessment of $118,285 (a 36.0% reduction).

Does Acs Group, INC. have any serious or willful violations? ▼

Yes. Acs Group, INC. has 25 serious violations, and 2 repeat violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.

What industry does Acs Group, INC. operate in? ▼

Acs Group, INC. operates in the Manufacturing sector (NAICS code 334513). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.

Where does Acs Group, INC. rank nationally on OSHA penalties? ▼

Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, Acs Group, INC. ranks #2,747 (the top 5% of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.

How does Acs Group, INC.'s safety record compare to industry average? ▼

Acs Group, INC.'s total OSHA penalty of $75,669 is above the Manufacturing industry average of $15,763 per employer (4.8x the average). The employer has 12 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Mobis North America in Detroit, MI is a similar manufacturing employer with $75,700 in current penalties.

Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.