Manufacturing · Wilmington, CA
Valero Refinery
According to OSHA enforcement records (2010–2026), Valero Refinery ranks #17,611 of 99,447 penalized U.S. employers by total current penalty, with a relatively clean safety record: 2 violations across 6 inspections.
- $20,000
- OSHA penalties
- 2
- Violations cited
- 6
- OSHA inspections
- #17,611
- of 99,447 penalized employers
Valero Refinery in Wilmington, CA has been the subject of 6 OSHA workplace inspections and 2 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $20,000. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.
The record in one line
OSHA has inspected Valero Refinery 6 times over 9 years, roughly once every couple of years. These inspections resulted in 2 violations, averaging 0.3 per inspection, on the lighter side. According to OSHA enforcement records, its total current penalty ranks #17,611 of 99,447 penalized U.S. employers (the top quarter of penalized employers nationally). Against the Manufacturing industry average of 3 inspections per employer, this runs well above peers (2.3x the sector average) on inspection frequency. For comparison, Continental in Sun Prairie, WI is another manufacturing employer with 0 OSHA inspections on record and $0 in current penalties.
- 0.3
- violations per inspection
- 0.0%
- of violations were serious
- #17,611
- of 99,447 penalized employers
Compliance score
- B OSHA safety compliance: 2 violations across 6 OSHA inspections (0.3 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.
Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.
How Valero Refinery compares on OSHA penalties
Total current penalty vs the Manufacturing per-employer average
- Valero Refinery
Valero Refinery
$20,000 in penalties
- Manufacturing avg
Manufacturing industry average (per employer)
$15,763 in penalties
What this shows Valero Refinery runs moderately above peers (1.3x the sector average) in total OSHA penalties.
Where this penalty ranks nationally
Total current OSHA penalty vs every U.S. employer with a nonzero penalty
$20,000 Bottom 18% least affordable more affordable than 18% of 99,447 U.S. employers with a penalty
Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.
Source U.S. Department of Labor, OSHA enforcement extracts · 2026
Does more inspection scrutiny mean more findings?
Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is Valero Refinery.
Valero Refinery in the Manufacturing enforcement ledger
Among 35,243 Manufacturing employers with OSHA penalties on file, Valero Refinery ranks #8,474 at $20,000 current penalty.
How Valero Refinery Compares
Valero Refinery's 0.33 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.
Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs moderately above peers (1.3x the sector average).
Enforcement detail
OSHA Inspection History
Total Inspections
6
First Inspection
2011-10-25
Last Inspection
2021-01-25
Inspection Span
9 yrs
Violations / Inspection
0.3
Avg Penalty / Inspection
$3,333
Industry Avg / Inspection
$6,093
What this shows 6 inspections over 9 years, averaging 0.3 violations per visit. That's $3,333 per inspection vs. the Manufacturing average of $6,093.
Enforcement detail
Violation Breakdown
0
Serious
0.0% of total
0
Willful
0.0% of total
0
Repeat
0.0% of total
2
Other-Than-Serious
100.0% of total
What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.
Enforcement detail
Penalty Analysis
Initial Penalty Assessed
$16,870
Current Penalty Amount
$20,000
Penalty Reduction
None
What this shows No reduction on record. The current penalty matches the original OSHA assessment.
Industry Safety Context: Manufacturing
How Valero Refinery compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.
| Metric | Valero Refinery | Industry Avg |
|---|---|---|
| Inspections | 6 | 2.6 |
| Violations | 2 | 8.0 |
| Total Penalty | $20,000 | $15,763 |
| Avg Penalty per Inspection | $3,333 | $6,093 |
Nationwide Manufacturing peers with similar penalties or inspection counts
Two OSHA-record peer sets for Valero Refinery, both outside CA so the neighborhoods are not geographic containment.
Similar current OSHA penalty
Nearest same-sector employers by current assessed penalty ($20,000 here).
Similar OSHA inspection count
Same-sector employers with a comparable inspection history outside this state (6 inspections here).
Nearby & Similar Employers in Manufacturing
Showing 5 of 44644 other employers tracked in this sector.
Compare Valero Refinery vs Wayne Farms, LLC - Decatur West side-by-side →
What to do with this record
Use Valero Refinery's enforcement history as one data point, not the whole picture.
- A single employer's record can look unusual in isolation. Compare Valero Refinery against Wayne Farms, LLC - Decatur West, a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
- See whether Valero Refinery's inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
- Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers
Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.
Frequently Asked Questions
Is Valero Refinery safe to work at? ▼
How many OSHA violations does Valero Refinery have? ▼
How many OSHA inspections has Valero Refinery had? ▼
What is the total penalty amount for Valero Refinery? ▼
What industry does Valero Refinery operate in? ▼
Where does Valero Refinery rank nationally on OSHA penalties? ▼
How does Valero Refinery's safety record compare to industry average? ▼
Data Sources & Methodology ▼
Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).
Source: OSHA Enforcement Data
Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.
Source: Wage and Hour Division (WHD)
Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.
Employer Matching
Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.