PlainWorker
Employers › NY

Manufacturing · Brentwood, NY

U.S. Nonwovens CORP.

According to OSHA enforcement records (2010–2026), U.S. Nonwovens CORP. ranks #14,539 of 99,447 penalized U.S. employers by total current penalty, with a concerning safety record: 4 violations across 3 inspections.

Top 25% by penalty75% serious
$23,500
OSHA penalties
4
Violations cited
3
OSHA inspections
#14,539
of 99,447 penalized employers

U.S. Nonwovens CORP. in Brentwood, NY has been the subject of 3 OSHA workplace inspections and 4 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $23,500. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected U.S. Nonwovens CORP. 3 times over 6 years, roughly once every couple of years. These inspections resulted in 4 violations, averaging 1.3 per inspection. According to OSHA enforcement records, its total current penalty ranks #14,539 of 99,447 penalized U.S. employers (the top quarter of penalized employers nationally). Of these, 3 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this sits roughly in line with peers (1.2x the sector average) on inspection frequency. For comparison, Point Blank Protective Apparel & Uniforms LLC in Guanica, PR is another manufacturing employer with 3 OSHA inspections on record and $23,500 in current penalties.

1.3
violations per inspection
75.0%
of violations were serious
#14,539
of 99,447 penalized employers

Compliance score

C 71/100
  • C OSHA safety compliance: 4 violations across 3 OSHA inspections (1.3 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.

Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.

Open my watchlist

How U.S. Nonwovens CORP. compares on OSHA penalties

Total current penalty vs the Manufacturing per-employer average

in penalties

What this shows U.S. Nonwovens CORP. runs moderately above peers (1.5x the sector average) in total OSHA penalties.

Source U.S. Department of Labor, OSHA enforcement extracts As of 2026

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$23,500 Bottom 15% least affordable more affordable than 15% of 99,447 U.S. employers with a penalty

$0–$5,000: 43,959 U.S. employers with a penalty (44%). Below this entry. $5,000–$10,000: 20,304 U.S. employers with a penalty (20%). Below this entry. $10,000–$15,000: 11,027 U.S. employers with a penalty (11%). Below this entry. $15,000–$20,000: 6,546 U.S. employers with a penalty (7%). Below this entry. $20,000–$25,000: 4,175 U.S. employers with a penalty (4%). This entry sits in this band. $25,000–$30,000: 2,877 U.S. employers with a penalty (3%). Above this entry. $30,000–$35,000: 2,036 U.S. employers with a penalty (2%). Above this entry. $35,000–$40,000: 1,493 U.S. employers with a penalty (2%). Above this entry. $40,000–$45,000: 1,095 U.S. employers with a penalty (1%). Above this entry. $45,000–$50,000: 785 U.S. employers with a penalty (1%). Above this entry. $50,000–$55,000: 5,150 U.S. employers with a penalty (5%). Above this entry. This employer $0 $55,000 every penalized U.S. employer, bucketed by value

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is U.S. Nonwovens CORP..

Frequently inspected, many findingsRarely inspected, many findingsFrequently inspected, clean recordBelow median on both3.03.033.03.0013.627.340.954.5OSHA inspectionsViolations citedSUBURBAN PLASTICS CO., OSHA inspections: 3 · Violations cited: 15GREEN BAY PACKAGING, OSHA inspections: 3 · Violations cited: 10DRAKE EXTRUSION, INC., OSHA inspections: 3 · Violations cited: 23TYSON FOODS, INC., OSHA inspections: 3 · Violations cited: 9VERSA-PAK, LTD., OSHA inspections: 3 · Violations cited: 10GONNELLA BAKING CO., OSHA inspections: 3 · Violations cited: 5INTEGRA-CAST, INC., OSHA inspections: 3 · Violations cited: 21D & S WELDING, LLC, OSHA inspections: 3 · Violations cited: 18FLORIDA FLOATS, INC., OSHA inspections: 3 · Violations cited: 11CHICAGO AEROSOL, LLC, OSHA inspections: 3 · Violations cited: 6NEOKRAFT SIGNS, INC., OSHA inspections: 3 · Violations cited: 13WALLNER EXPAC, INC., OSHA inspections: 3 · Violations cited: 7MEGAWALL CORPORATION, OSHA inspections: 3 · Violations cited: 34ADVANCE INDUSTRIAL M…, OSHA inspections: 3 · Violations cited: 16SOUTHERN WILD GAME H…, OSHA inspections: 3 · Violations cited: 11NEW STANDARD CORPORA…, OSHA inspections: 3 · Violations cited: 4JAMES SKINNER BAKING…, OSHA inspections: 3 · Violations cited: 6NORDYNE, OSHA inspections: 3 · Violations cited: 8LOFLIN HANDLE CO., INC, OSHA inspections: 3 · Violations cited: 52STRUCTURAL PRESTRESS…, OSHA inspections: 3 · Violations cited: 1U.S. Nonwovens CORP., OSHA inspections: 3 · Violations cited: 4
U.S. Nonwovens CORP. has 3 OSHA inspections on record and 4 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

U.S. Nonwovens CORP. in the Manufacturing enforcement ledger

In Manufacturing, U.S. Nonwovens CORP. sits at penalty rank #7,092 of 35,243 penalized establishments ($23,500 assessed).

How U.S. Nonwovens CORP. Compares

U.S. Nonwovens CORP.'s 1.33 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs moderately above peers (1.5x the sector average).

Enforcement detail

OSHA Inspection History

Total Inspections

3

First Inspection

2015-03-06

Last Inspection

2020-10-14

Inspection Span

6 yrs

Violations / Inspection

1.3

Avg Penalty / Inspection

$7,833

Industry Avg / Inspection

$6,093

What this shows 3 inspections over 6 years, averaging 1.3 violations per visit. That's $7,833 per inspection vs. the Manufacturing average of $6,093.

Enforcement detail

Violation Breakdown

3

Serious

75.0% of total

0

Willful

0.0% of total

1

Repeat

25.0% of total

0

Other-Than-Serious

0.0% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Enforcement detail

Penalty Analysis

Initial Penalty Assessed

$58,000

Current Penalty Amount

$23,500

Penalty Reduction

59.5%

What this shows Penalties were reduced by $34,500 from the initial assessment of $58,000. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Industry Safety Context: Manufacturing

How U.S. Nonwovens CORP. compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric U.S. Nonwovens CORP. Industry Avg
Inspections 3 2.6
Violations 4 8.0
Total Penalty $23,500 $15,763
Avg Penalty per Inspection $7,833 $6,093
View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for U.S. Nonwovens CORP., both outside NY so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($23,500 here).

VSS Countertops, INC. $23,500 CA Point Blank Protective Apparel & Uniforms LLC $23,500 PR Sodecia Automotive Auburn LP $23,500 AL Freightcar Alabama, LLC $23,500 AL

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (3 inspections here).

Suburban Plastics CO. 3 insp. Elgin, IL Green Bay Packaging 3 insp. Lebanon, OH Drake Extrusion, INC. 3 insp. Ridgeway, VA Tyson Foods, INC. 3 insp. South Hutchinson, KS

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

VSS Countertops, INC.
Sacramento, CA
4 inspections $23,500
Point Blank Protective Apparel & Uniforms LLC
Guanica, PR
3 inspections $23,500
Sodecia Automotive Auburn LP
Auburn, AL
3 inspections $23,500
Freightcar Alabama, LLC
Cherokee, AL
5 inspections $23,500
Chassis CORP DBA Chassix INC
Port Huron, MI
2 inspections $23,500

Compare U.S. Nonwovens CORP. vs VSS Countertops, INC. side-by-side →

What to do with this record

Use U.S. Nonwovens CORP.'s enforcement history as one data point, not the whole picture.

  • A single employer's record can look unusual in isolation. Compare U.S. Nonwovens CORP. against VSS Countertops, INC., a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
  • See whether U.S. Nonwovens CORP.'s inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
  • Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is U.S. Nonwovens CORP. safe to work at? ▼
Based on OSHA records, U.S. Nonwovens CORP.'s workplace safety record is concerning, with multiple serious compliance issues. The employer has 4 violations across 3 inspections, including 3 serious violations. Compared to Manufacturing industry peers, this is above average for penalties. Review the full inspection history below for details.
How many OSHA violations does U.S. Nonwovens CORP. have? ▼
U.S. Nonwovens CORP. has 4 OSHA violations on record, including 3 serious, 0 willful, and 1 repeat violations. The total current penalty amount is $23,500.
How many OSHA inspections has U.S. Nonwovens CORP. had? ▼
U.S. Nonwovens CORP. has had 3 OSHA inspections, with the first recorded on 2015-03-06 and the most recent on 2020-10-14. This averages 1.3 violations per inspection.
What is the total penalty amount for U.S. Nonwovens CORP.? ▼
U.S. Nonwovens CORP. has been assessed $23,500 in current OSHA penalties, reduced from an initial assessment of $58,000 (a 59.5% reduction).
Does U.S. Nonwovens CORP. have any serious or willful violations? ▼
Yes. U.S. Nonwovens CORP. has 3 serious violations, and 1 repeat violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.
What industry does U.S. Nonwovens CORP. operate in? ▼
U.S. Nonwovens CORP. operates in the Manufacturing sector (NAICS code 313230). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.
Where does U.S. Nonwovens CORP. rank nationally on OSHA penalties? ▼
Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, U.S. Nonwovens CORP. ranks #14,539 (the top quarter of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.
How does U.S. Nonwovens CORP.'s safety record compare to industry average? ▼
U.S. Nonwovens CORP.'s total OSHA penalty of $23,500 is above the Manufacturing industry average of $15,763 per employer (1.5x the average). The employer has 3 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Point Blank Protective Apparel & Uniforms LLC in Guanica, PR is a similar manufacturing employer with $23,500 in current penalties.
Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.

Verify with OSHA establishment search →

Every figure on PlainWorker is rendered directly from official U.S. Department of Labor OSHA and Wage & Hour Division enforcement records, no number is typed in by an editor. This employer's ratios (penalty-per-violation, industry comparisons) are computed live from the 3 inspections on record. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of 2026.