Manufacturing · Lodi, CA

Tusco Casting Corporation

According to OSHA enforcement records (2010–2026), Tusco Casting Corporation ranks #66,275 of 99,447 penalized U.S. employers by total current penalty, with a relatively clean safety record: 2 violations across 4 inspections.

Lower half by penalty50% serious

Compiled by Plainworker · September 6, 2026

$3,263
OSHA penalties: 2
Violations cited: 4
OSHA inspections: #66,275
of 99,447 penalized employers

Tusco Casting Corporation in Lodi, CA has been the subject of 4 OSHA workplace inspections and 2 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $3,263. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected Tusco Casting Corporation 4 times over 6 years, roughly once every couple of years. These inspections resulted in 2 violations, averaging 0.5 per inspection, on the lighter side. According to OSHA enforcement records, its total current penalty ranks #66,275 of 99,447 penalized U.S. employers (the lower half of penalized employers nationally). Of these, 1 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this runs moderately above peers (1.5x the sector average) on inspection frequency. For comparison, Michigan Metal Coatings Company in Port Huron, MI is another manufacturing employer with 3 OSHA inspections on record and $3,265 in current penalties.

0.5
violations per inspection: 50.0%
of violations were serious: #66,275
of 99,447 penalized employers

Compliance score

B 83/100

B OSHA safety compliance: 2 violations across 4 OSHA inspections (0.5 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.

Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.

Open my watchlist

Tusco Casting Corporat…

$3,263
Manufacturing avg

$15,763

What this shows Tusco Casting Corporation runs well below peers (0.21x the sector average) in total OSHA penalties.

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$3,263 Top 33% most affordable more affordable than 67% of 99,447 U.S. employers with a penalty

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is Tusco Casting Corporation.

Tusco Casting Corporation has 4 OSHA inspections on record and 2 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

Tusco Casting Corporation in the Manufacturing enforcement ledger

Among 35,243 Manufacturing employers with OSHA penalties on file, Tusco Casting Corporation ranks #26,675 at $3,263 current penalty.

How Tusco Casting Corporation Compares

Tusco Casting Corporation's 0.50 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs well below peers (0.21x the sector average).

Total Inspections

First Inspection

2013-03-27

Last Inspection

2019-02-19

Inspection Span

6 yrs

Violations / Inspection

0.5

Avg Penalty / Inspection

$816

Industry Avg / Inspection

$6,093

What this shows 4 inspections over 6 years, averaging 0.5 violations per visit. That's $816 per inspection vs. the Manufacturing average of $6,093.

Serious

50.0% of total

Willful

0.0% of total

Repeat

0.0% of total

Other-Than-Serious

50.0% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Initial Penalty Assessed

$3,373

Current Penalty Amount

$3,263

Penalty Reduction

3.3%

What this shows Penalties were reduced by $110 from the initial assessment of $3,373. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Industry Safety Context: Manufacturing

How Tusco Casting Corporation compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric	Tusco Casting Corporation	Industry Avg
Inspections	4	2.6
Violations	2	8.0
Total Penalty	$3,263	$15,763
Avg Penalty per Inspection	$816	$6,093

View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for Tusco Casting Corporation, both outside CA so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($3,263 here).

Gmack Designs LLC $3,263 SC James and Company Limited Liability Company $3,264 AL Shatone $3,264 GA Precision Sheet Metal Supply, INC. $3,265 VA

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (4 inspections here).

Hanover Foods Corporation 4 insp. Centre Hall, PA Starkist Samoa CO. 4 insp. Pago Pago, AS Dyna-Mix, INC. 4 insp. Tyler, TX Seneca Foods Corporation 4 insp. Gillett, WI

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

Gmack Designs LLC

Lake City, SC

2 inspections $3,263

James and Company Limited Liability Company

Precision Sheet Metal Supply, INC.

Herndon, VA

2 inspections $3,265

Michigan Metal Coatings Company

Port Huron, MI

3 inspections $3,265

Compare Tusco Casting Corporation vs Gmack Designs LLC side-by-side →

What to do with this record

Use Tusco Casting Corporation's enforcement history as one data point, not the whole picture.

A single employer's record can look unusual in isolation. Compare Tusco Casting Corporation against Gmack Designs LLC, a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
See whether Tusco Casting Corporation's inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is Tusco Casting Corporation safe to work at? ▼

Based on OSHA records, Tusco Casting Corporation's workplace safety record is relatively clean, with fewer violations than typical. The employer has 2 violations across 4 inspections, including 1 serious violations. Compared to Manufacturing industry peers, this is below average for penalties. Review the full inspection history below for details.

How many OSHA violations does Tusco Casting Corporation have? ▼

Tusco Casting Corporation has 2 OSHA violations on record, including 1 serious, 0 willful, and 0 repeat violations. The total current penalty amount is $3,263.

How many OSHA inspections has Tusco Casting Corporation had? ▼

Tusco Casting Corporation has had 4 OSHA inspections, with the first recorded on 2013-03-27 and the most recent on 2019-02-19. This averages 0.5 violations per inspection.

What is the total penalty amount for Tusco Casting Corporation? ▼

Tusco Casting Corporation has been assessed $3,263 in current OSHA penalties, reduced from an initial assessment of $3,373 (a 3.3% reduction).

Does Tusco Casting Corporation have any serious or willful violations? ▼

Yes. Tusco Casting Corporation has 1 serious violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.

What industry does Tusco Casting Corporation operate in? ▼

Tusco Casting Corporation operates in the Manufacturing sector (NAICS code 331513). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.

Where does Tusco Casting Corporation rank nationally on OSHA penalties? ▼

Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, Tusco Casting Corporation ranks #66,275 (the lower half of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.

How does Tusco Casting Corporation's safety record compare to industry average? ▼

Tusco Casting Corporation's total OSHA penalty of $3,263 is below the Manufacturing industry average of $15,763 per employer. The employer has 4 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Michigan Metal Coatings Company in Port Huron, MI is a similar manufacturing employer with $3,265 in current penalties.

Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.