Manufacturing · Butler, PA

On the Edge, INC.

According to OSHA enforcement records (2010–2026), On the Edge, INC. ranks #42,425 of 99,447 penalized U.S. employers by total current penalty, with a concerning safety record: 10 violations across 2 inspections.

Upper half by penalty80% serious

Compiled by Plainworker · September 6, 2026

$7,758
OSHA penalties: 10
Violations cited: 2
OSHA inspections: #42,425
of 99,447 penalized employers

On the Edge, INC. in Butler, PA has been the subject of 2 OSHA workplace inspections and 10 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $7,758. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected On the Edge, INC. 2 times across a longer 7-year span, an infrequent cadence. These inspections resulted in 10 violations, averaging 5.0 per inspection - a notably high rate. According to OSHA enforcement records, its total current penalty ranks #42,425 of 99,447 penalized U.S. employers (the upper half of penalized employers nationally). Of these, 8 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this runs moderately below peers (0.8x the sector average) on inspection frequency. For comparison, Sandy Alexander in Clifton, NJ is another manufacturing employer with 2 OSHA inspections on record and $7,758 in current penalties.

5.0
violations per inspection: 80.0%
of violations were serious: #42,425
of 99,447 penalized employers

Compliance score

F 17/100

F OSHA safety compliance: 10 violations across 2 OSHA inspections (5.0 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.

Channels are separate federal datasets: a dimension marked not applicable simply has no record in that dataset for this employer, not a good or bad score.

Open my watchlist

On the Edge, INC.

$7,758
Manufacturing avg

$15,763

What this shows On the Edge, INC. runs moderately below peers (0.5x the sector average) in total OSHA penalties.

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$7,758 Bottom 43% least affordable more affordable than 43% of 99,447 U.S. employers with a penalty

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is On the Edge, INC..

On the Edge, INC. has 2 OSHA inspections on record and 10 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

On the Edge, INC. in the Manufacturing enforcement ledger

Among 35,243 Manufacturing employers with OSHA penalties on file, On the Edge, INC. ranks #18,579 at $7,758 current penalty.

How On the Edge, INC. Compares

On the Edge, INC.'s 5.00 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs moderately below peers (0.5x the sector average).

Total Inspections

First Inspection

2011-10-28

Last Inspection

2018-12-13

Inspection Span

7 yrs

Violations / Inspection

5.0

Avg Penalty / Inspection

$3,879

Industry Avg / Inspection

$6,093

What this shows 2 inspections over 7 years, averaging 5.0 violations per visit. That's $3,879 per inspection vs. the Manufacturing average of $6,093.

Serious

80.0% of total

Willful

0.0% of total

Repeat

0.0% of total

Other-Than-Serious

20.0% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Initial Penalty Assessed

$12,813

Current Penalty Amount

$7,758

Penalty Reduction

39.5%

What this shows Penalties were reduced by $5,055 from the initial assessment of $12,813. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Industry Safety Context: Manufacturing

How On the Edge, INC. compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric	On the Edge, INC.	Industry Avg
Inspections	2	2.6
Violations	10	8.0
Total Penalty	$7,758	$15,763
Avg Penalty per Inspection	$3,879	$6,093

View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for On the Edge, INC., both outside PA so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($7,758 here).

Hofmann Sausage Company LLC $7,758 NY Sandy Alexander $7,758 NJ Little Colorado LLC $7,759 CO Jeskey, LLC $7,757 CT

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (2 inspections here).

Becton Dickinson & CO. 2 insp. Holdrege, NE Granite Masters, INC. 2 insp. Suwanee, GA Fort Worth F&D Head Company 2 insp. Fort Worth, TX Lexicon, INC. 2 insp. Armorel, AR

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

Hofmann Sausage Company LLC

Compare On the Edge, INC. vs Hofmann Sausage Company LLC side-by-side →

What to do with this record

Use On the Edge, INC.'s enforcement history as one data point, not the whole picture.

A single employer's record can look unusual in isolation. Compare On the Edge, INC. against Hofmann Sausage Company LLC, a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
See whether On the Edge, INC.'s inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
Before you accept a job or raise a safety concern, search any employer for its own OSHA inspection history the same way you found this one. Search employers

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is On the Edge, INC. safe to work at? ▼

Based on OSHA records, On the Edge, INC.'s workplace safety record is concerning, with multiple serious compliance issues. The employer has 10 violations across 2 inspections, including 8 serious violations. Compared to Manufacturing industry peers, this is below average for penalties. Review the full inspection history below for details.

How many OSHA violations does On the Edge, INC. have? ▼

On the Edge, INC. has 10 OSHA violations on record, including 8 serious, 0 willful, and 0 repeat violations. The total current penalty amount is $7,758.

How many OSHA inspections has On the Edge, INC. had? ▼

On the Edge, INC. has had 2 OSHA inspections, with the first recorded on 2011-10-28 and the most recent on 2018-12-13. This averages 5.0 violations per inspection.

What is the total penalty amount for On the Edge, INC.? ▼

On the Edge, INC. has been assessed $7,758 in current OSHA penalties, reduced from an initial assessment of $12,813 (a 39.5% reduction).

Does On the Edge, INC. have any serious or willful violations? ▼

Yes. On the Edge, INC. has 8 serious violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.

What industry does On the Edge, INC. operate in? ▼

On the Edge, INC. operates in the Manufacturing sector (NAICS code 332322). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.

Where does On the Edge, INC. rank nationally on OSHA penalties? ▼

Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, On the Edge, INC. ranks #42,425 (the upper half of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.

How does On the Edge, INC.'s safety record compare to industry average? ▼

On the Edge, INC.'s total OSHA penalty of $7,758 is below the Manufacturing industry average of $15,763 per employer. The employer has 2 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Sandy Alexander in Clifton, NJ is a similar manufacturing employer with $7,758 in current penalties.

Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.