Manufacturing · Denison, TX

Acs Manufacturing, INC.

According to OSHA enforcement records (2010–2026), Acs Manufacturing, INC. ranks #1,050 of 99,447 penalized U.S. employers by total current penalty, with a concerning safety record: 28 violations across 8 inspections.

Top 1% by penalty75% serious

Compiled by Plainworker · September 6, 2026

$137,670
OSHA penalties: 28
Violations cited: 8
OSHA inspections: #1,050
of 99,447 penalized employers

Acs Manufacturing, INC. in Denison, TX has been the subject of 8 OSHA workplace inspections and 28 citations since 2010, according to enforcement records from the U.S. Department of Labor. Total penalties assessed: $137,670. Separately, the Department of Labor's Wage and Hour Division found $0 in back wages owed to an undisclosed number of workers. All enforcement data below is sourced from the DOL public enforcement databases at data.dol.gov.

The record in one line

OSHA has inspected Acs Manufacturing, INC. 8 times over 9 years, roughly once every couple of years. These inspections resulted in 28 violations, averaging 3.5 per inspection, above what's typical for a single visit. According to OSHA enforcement records, its total current penalty ranks #1,050 of 99,447 penalized U.S. employers (the top 1% of penalized employers nationally). Of these, 21 were classified as serious - indicating hazards that could cause death or serious harm. Against the Manufacturing industry average of 3 inspections per employer, this runs well above peers (3.1x the sector average) on inspection frequency. The Department of Labor also found wage violations, with $0 in back wages owed to an undisclosed number of workers. For comparison, Saehaesung Alabama, INC. in Andalusia, AL is another manufacturing employer with 6 OSHA inspections on record and $137,800 in current penalties.

3.5
violations per inspection: 75.0%
of violations were serious: #1,050
of 99,447 penalized employers: $0
in back wages recovered

Compliance score

C 66/100

F OSHA safety compliance: 28 violations across 8 OSHA inspections (3.5 per inspection), vs. national p10 0.0 (best) / p90 5.5 (worst) among 145,626 inspected employers.
A Wage & hour compliance: $0 in back wages owed across 1 WHD case ($0 per case), vs. national p10 $2K (best) / p90 $58K (worst) among 91,622 employers with a WHD case on file.

Open my watchlist

Acs Manufacturing, INC.

$137,670
Manufacturing avg

$15,763

What this shows Acs Manufacturing, INC. runs far above peers (8.7x the sector average) in total OSHA penalties.

Where this penalty ranks nationally

Total current OSHA penalty vs every U.S. employer with a nonzero penalty

$137,670 Bottom 1% least affordable more affordable than 1% of 99,447 U.S. employers with a penalty

Each bar is a $5K-wide band; taller bars hold more U.S. employers with a penalty. The dashed line + filled bar mark this entry. Hover or tap any bar for its full count, share, and where it sits relative to this entry.

Source U.S. Department of Labor, OSHA enforcement extracts · 2026

Does more inspection scrutiny mean more findings?

Each dot is one of 21 Manufacturing employers with an OSHA inspection on record, placed by inspections and violations cited. The highlighted dot is Acs Manufacturing, INC..

Acs Manufacturing, INC. has 8 OSHA inspections on record and 28 violations cited. The crosshair marks the median among these Manufacturing peers. Across this sector's tracked employers, more inspections is moderately associated with more violations found -- not a coincidence, but not a guarantee either.

Acs Manufacturing, INC. in the Manufacturing enforcement ledger

Manufacturing sector: Acs Manufacturing, INC. is the #580 heaviest OSHA penalty carrier of 35,243 employers with nonzero fines ($137,670).

Combined federal exposure here: $137,670 OSHA penalties plus $0 WHD back wages (0.0% of the combined total is wage recovery).

How Acs Manufacturing, INC. Compares

Acs Manufacturing, INC.'s 3.50 violations per inspection compares to the Manufacturing sector average of 8.0 violations per employer.

Against the Manufacturing industry average of $15,763 per employer, this employer's current OSHA penalty runs far above peers (8.7x the sector average).

Total Inspections

First Inspection

2016-11-03

Last Inspection

2025-08-06

Inspection Span

9 yrs

Violations / Inspection

3.5

Avg Penalty / Inspection

$17,209

Industry Avg / Inspection

$6,093

What this shows 8 inspections over 9 years, averaging 3.5 violations per visit. That's $17,209 per inspection vs. the Manufacturing average of $6,093.

Serious

75.0% of total

Willful

0.0% of total

Repeat

17.9% of total

Other-Than-Serious

7.1% of total

What this shows Serious violations involve hazards that could cause death or serious physical harm. Willful violations indicate intentional or knowing disregard of the law. Repeat violations are for hazards previously cited within the past 5 years.

Initial Penalty Assessed

$251,044

Current Penalty Amount

$137,670

Penalty Reduction

45.2%

Combined Impact (OSHA + WHD)

$137,670

What this shows Penalties were reduced by $113,374 from the initial assessment of $251,044. Reductions may result from informal settlements, formal contests, or negotiated agreements with OSHA.

Wage & Hour Findings

WHD Cases

Back Wages Owed

Employees Affected

WHD Violations

Industry Safety Context: Manufacturing

How Acs Manufacturing, INC. compares to the Manufacturing sector, which has 44,645 employers tracked by PlainWorker.

Metric	Acs Manufacturing, INC.	Industry Avg
Inspections	8	2.6
Violations	28	8.0
Total Penalty	$137,670	$15,763
Avg Penalty per Inspection	$17,209	$6,093

View all 44,645 employers in Manufacturing →

Nationwide Manufacturing peers with similar penalties or inspection counts

Two OSHA-record peer sets for Acs Manufacturing, INC., both outside TX so the neighborhoods are not geographic containment.

Similar current OSHA penalty

Nearest same-sector employers by current assessed penalty ($137,670 here).

Saehaesung Alabama, INC. $137,800 AL Fixtureone $137,530 PA Nichiha USA, INC. $137,502 GA United Foods International (USA), INC. $137,905 CA

Similar OSHA inspection count

Same-sector employers with a comparable inspection history outside this state (8 inspections here).

National Manufacturing CO., INC 8 insp. Chatham, NJ Ernst Metal Technologies LLC 8 insp. Moraine, OH Daewon America, INC. 8 insp. Opelika, AL Arcelormittal-Weirton, LLC 8 insp. Weirton, WV

Nearby & Similar Employers in Manufacturing

Showing 5 of 44644 other employers tracked in this sector.

Arrayit Corporation

Sunnyvale, CA

0 inspections $0

Saehaesung Alabama, INC.

Andalusia, AL

6 inspections $137,800

Fixtureone

Philadelphia, PA

2 inspections $137,530

United Foods International (USA), INC.

Hayward, CA

3 inspections $137,905

United States Pipe and Foundry Company, LLC

Bessemer, AL

11 inspections $137,906

Compare Acs Manufacturing, INC. vs Arrayit Corporation side-by-side →

What to do with this record

Use Acs Manufacturing, INC.'s enforcement history as one data point, not the whole picture.

A single employer's record can look unusual in isolation. Compare Acs Manufacturing, INC. against Arrayit Corporation, a similarly-sized employer in the same sector, before drawing conclusions. Compare side-by-side
See whether Acs Manufacturing, INC.'s inspection and penalty record is typical for Manufacturing or an outlier against the sector's own average. View the Manufacturing sector
Acs Manufacturing, INC. also carries $0 in Wage and Hour Division back-wages, a separate enforcement track from OSHA safety violations. How wage-theft enforcement works

Figures reflect closed OSHA and WHD federal enforcement actions on record (2010–2026); not every workplace issue results in an inspection or investigation.

Frequently Asked Questions

Is Acs Manufacturing, INC. safe to work at? ▼

Based on OSHA records, Acs Manufacturing, INC.'s workplace safety record is concerning, with multiple serious compliance issues. The employer has 28 violations across 8 inspections, including 21 serious violations. Compared to Manufacturing industry peers, this is above average for penalties. Review the full inspection history below for details.

How many OSHA violations does Acs Manufacturing, INC. have? ▼

Acs Manufacturing, INC. has 28 OSHA violations on record, including 21 serious, 0 willful, and 5 repeat violations. The total current penalty amount is $137,670.

How many OSHA inspections has Acs Manufacturing, INC. had? ▼

Acs Manufacturing, INC. has had 8 OSHA inspections, with the first recorded on 2016-11-03 and the most recent on 2025-08-06. This averages 3.5 violations per inspection.

What is the total penalty amount for Acs Manufacturing, INC.? ▼

Acs Manufacturing, INC. has been assessed $137,670 in current OSHA penalties, reduced from an initial assessment of $251,044 (a 45.2% reduction). Additionally, $0 in back wages were owed through WHD enforcement.

Does Acs Manufacturing, INC. have any serious or willful violations? ▼

Yes. Acs Manufacturing, INC. has 21 serious violations, and 5 repeat violations. Serious violations involve hazards likely to cause death or serious physical harm. Willful violations indicate the employer intentionally or knowingly disregarded the law.

Has Acs Manufacturing, INC. been cited for wage theft? ▼

Yes. The Department of Labor's Wage and Hour Division has recorded 1 enforcement case against Acs Manufacturing, INC., resulting in $0 in back wages owed to an undisclosed number of workers. These cases involve violations of federal labor laws including minimum wage, overtime, and other worker protections.

What industry does Acs Manufacturing, INC. operate in? ▼

Acs Manufacturing, INC. operates in the Manufacturing sector (NAICS code 332439). This industry has 44,645 employers tracked by PlainWorker, with 115,492 total OSHA inspections and $703.72M in cumulative penalties.

What should I do if Acs Manufacturing, INC. owes me wages? ▼

If you believe Acs Manufacturing, INC. owes you wages, you can file a complaint with the Department of Labor's Wage and Hour Division at dol.gov/agencies/whd/contact/complaints or by calling 1-866-487-9243. WHD investigates violations of the Fair Labor Standards Act including unpaid minimum wage, overtime, and unauthorized deductions. The DOL has previously found $0 in back wages owed by this employer across 1 case.

Where does Acs Manufacturing, INC. rank nationally on OSHA penalties? ▼

Among the 99,447 U.S. employers with a nonzero current OSHA penalty in PlainWorker's corpus, Acs Manufacturing, INC. ranks #1,050 (the top 1% of penalized employers nationally). The ordinal is a live COUNT of employers with a lower total_current_penalty; see the methodology page for the exact derivation.

How does Acs Manufacturing, INC.'s safety record compare to industry average? ▼

Acs Manufacturing, INC.'s total OSHA penalty of $137,670 is above the Manufacturing industry average of $15,763 per employer (8.7x the average). The employer has 8 inspections compared to the industry average of 2.6 per employer. For a direct comparison, Saehaesung Alabama, INC. in Andalusia, AL is a similar manufacturing employer with $137,800 in current penalties.

Data Sources & Methodology ▼

Data as of 2026. Source: U.S. Department of Labor (OSHA, WHD).

Source: OSHA Enforcement Data

Inspection and violation records from the Occupational Safety and Health Administration (OSHA), U.S. Department of Labor, covering the period 2010–2026. Includes inspection dates, violation types (serious, willful, repeat, other-than-serious), and penalty amounts. Penalties shown are current assessed amounts and may differ from original citations due to settlement, contest, or reduction.

Source: Wage and Hour Division (WHD)

Compliance actions from the WHD, covering enforcement of the Fair Labor Standards Act (FLSA), including minimum wage, overtime, and child labor violations. Back wages represent amounts owed to affected employees as determined by WHD investigations.

Employer Matching

Employers are matched across OSHA and WHD datasets by name, state, and city. Employers included in PlainWorker have 2 or more OSHA inspections or $1,000+ in WHD back wages. Data is updated monthly from data.dol.gov.